Product ID:ALKYD METAL GRIP PRIMER, 215
MSDS Date:01/01/1996
FSC:8010
NIIN:00N056812
MSDS Number: CFZLS

Emergency Phone: 818-442-7289

Info Phone: 818-459-4675

Preparer: J THOMAS

Cage: 52100

Telephone: 800-272-4687/818-442-7269

Cage: 52100

KEROSENE (PETROLEUM) HYDROTREATED; (MINERAL SPIRITS,

CAS: 64742-47-8

RTECS: OA5504000

Fraction By Weight: 40%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRIT TO SKIN, EYES &
INTESTINAL SYS. INHAL: ADVERSE HEALTH EFFECTS FROM VAPOR OR SPRAY
MIST IN POORLY VENTILATED AREAS MAY INCLUDE IRRITATION OF MUCOUS
MEMBRANES OF NOSE, THROAT, & R ESPIRATORY TRACT & SYMPTOMS OF
HEADACHE& NAUSEA. EYES: MAY CAUSE IRRITATION. SKIN: PROLONGED &
RPTD (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CONT MAY CAUSE IRRIT. SKIN ABSORP:
REDNESS, DRYING OF SKIN OR OTHER SIGNS OF IRRITATION OR CONTACT
DERMATITIS. INGEST: CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA,
VOMITING, AND DIARRHEA.
Medical Cond Aggravated by Exposure:NONE.

First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH W/WATER FOR @ LST 15
MINS. REFER TO PHYS. SKIN: REMOVE WITH SOAP & WATER. REMOVE ALL
CONTAMINATED CLOTHING. INGEST: DRINK 1-2 GLASSES OF WATER TO
DILUTE. DO NOT INDUCE VOMITING. CONSULT PHYS OR POISON CONTROL
CENTER. TREAT SYMPTOMATICALLY.

Flash Point Method:SCC
Flash Point:105F,41C
Lower Limits:1.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . DURING EMERGENCIES CONDITIONS OVEREXPOSURE MAY CAUSE
IMMED/DELAYED HEALTH PROBLEMS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & BE IGNITED BY HEAT. OPEN FLAME/OTHER IGNIT SOURCES. KEEP
CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT, SPKS, (SUPDAT)

Spill Release Procedures:DIKE. CONTAIN OR ABSORB WITH INERT MATERIAL,
SAND, VERMICULITE, ETC. TRANSFER TO CONTAINERS FOR RECOVERY OR
DISPOSAL. PREVENT RUNOFF TO SEWERS, STREAMS, OR OTHER BODIES OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT EXPOSE TO EXTREME TEMPERATURES.
DO NOT ALLOW MATERIAL TO FREEZE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED
EXPOSURE TO LEVELS ABOVE TLV.

Respiratory Protection:NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED, USE
NIOSH APPROVED ORGANIC VAPOR AND MIST PROTECTION.
Ventilation:USE ADEQUATE VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:RESISTANT GLOVES SUCH AS POLYETHYLENE.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM.
Supplemental Safety and Health
EXPLO HAZ:ELEC EQUIP & OPEN FLAMES. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.

Boiling Pt:B.P. Text:350F,177C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.2 (H*2O=1)
VOC Pounds/Gallon:528
VOC Grams/Liter:4.41
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NONE
Appearance and Odor:TYPICAL FOR SOLVENT BASED COATING.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OR BYPRODUCTS: MAY FORM TOXIC
MATERIALS CARBON DIOXIDE, CARBON MONOXIDE, ETC.

Waste Disposal Methods:FOLLOW ALL LOCAL, STATE OR FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.